Indian, Russian scientists to decide Tuesday on rocket launch

CHENNAI - With a leak in one of the engine valves forcing postponement of the GSLV rocket launch, Indian and Russian space scientists are to conduct some tests Tuesday to determine the extent of damage, an official said Monday.

The scientists will measure the extent of leak in one of the valves of the Russian-made cryogenic engine of the geosynchronous satellite launch vehicle (GSLV) rocket that was to place an advanced communications satellite into orbit Monday.

The Indian Space Research Organisation (ISRO) Sunday decided to postpone the rocket’s launch after it detected the leak during the pre-countdown mandatory tests even as the 51-metre tall rocket was on the launch pad at Sriharikota.

The rocket was to carry GSAT-5P, an advanced communications satellite meant to retire an earlier one sent up in 1999 and ensure continuity of telecom, TV and weather services.

S. Satish, a director at ISRO, said: There is a small team of Russian experts at the rocket port whenever a rocket is flown with their cryogenic engine.

According to ISRO officials, some tests will be done Tuesday to measure the extent of valve leak and a decision on the rocket launch will be taken only after studying the results.

May be tomorrow (Tuesday) evening we may have a decision, an ISRO official, on condition of anonymity, told IANS.

He said tests and discussions with the Russian scientists will go hand in hand Tuesday at the Sriharikota rocket launch centre, around 80 km from here.

The Russians had supplied seven cryogenic engines, of which five were used in the earlier GSLV rockets.

The 29-hour countdown, planned to commence at 11.01 a.m. Sunday, was not authorised by the Launch Authorisation Board. The board met Sunday forenoon at the Sriharikota rocket launch centre to review the results of pre-countdown checks and decided against proceeding with the mission.

Sources close to ISRO told IANS that there are standard leak rates for valves. Only when this exceeds the minimum level are alarm bells sounded.

ISRO officials said that since the cryogenic engine is supplied by Russia, their expertise and consent will be obtained on how to plug the leak.

If at all the valve has to be replaced, then it has to be supplied by the Russians, the sources said.

“The components of Indian cryogenic engine are of varied specifications and will not fit the Russian made one. The Russians had supplied the seven cryogenic engines long ago,” the source told IANS.

According to officials, dismantling of the cryogenic engine with the faulty valve and fitting the rocket with another one will be a tedious affair or even impossible due to its complexity.

According to ISRO officials, a delay in the GSAT-5P launch will not affect any of its customers as the earlier satellite INSAT-2E is still operational.

According to ISRO officials, the GSLV rocket has three stages. The first stage is fired by solid fuel and hugged by four strap-on motors fired by liquid fuel. The strap-on motors give additional thrust during the lift off and the initial phase of the rocket’s flight.

The second stage/engine is fired by liquid fuel and the third and complex stage is the cryogenic engine powered by liquid hydrogen as fuel and liquid oxygen as oxidizer.

The solid fuel is cast ready while the liquid fuel is filled barely hours before the rocket’s blast-off.

–Indo Asian News Service